Violation code

396.5B-HLIW

Hubs - Oil and/or Grease Leaking from hub - inner wheel

Vehicle Maintenance2Non-OOS· SMS Appendix A v3.20

396.5B-HLIW is a Wheels, Studs, Clamps, Etc. violation under 49 CFR §396.5B-HLIW. It falls in the Vehicle Maintenance BASIC with a severity weight of 2/10. Nationally it was cited 16,382 times in the last five years, with an OOS rate of 36.8%.

📊

National roadside inspection stats

as of 6/20/2026

Inspections

14,358

that found this code

Violations

16,382

total written

OOS rate

36.8%

6,023 OOS

Source: FMCSA roadside inspection data (last 5 years). The OOS rate is the share of these violations that led the officer to mark the driver or vehicle out of service.

Violation group: Wheels, Studs, Clamps, Etc.
Regulation §: 396.5B-HLIW
Severity weight: 2
Used in SMS: Yes
Status: Active
Updated: 6/20/2026

Last updated June 2026

⚡

Think this violation was written incorrectly?

Generate a polished DataQs challenge letter for 396.5B-HLIW in about 5 seconds. AI quotes the CFR, predicts your grant chance.

⚡ Draft a challenge →

Notes

DSMS: N

📚

Challenging 396.5B-HLIW through FMCSA DataQs

If this violation was written incorrectly, here are the angles trucking-safety managers use to contest it. Playbook: Vehicle Maintenance (general).

Relevant 49 CFR49 CFR § 396.5

Lubrication

“Every motor carrier shall ensure that each motor vehicle subject to its control is properly lubricated and free of oil and grease leaks.”

Common ways to challenge this code

Pre-trip inspection showed compliant brakes
The driver's pre-trip DVIR documented compliant brake adjustment and operation. The cited defect arose en route or was misclassified at roadside.
Evidence that wins
- ✓Driver Vehicle Inspection Report (DVIR) from that date
- ✓Repair invoice or shop record
- ✓Post-citation re-inspection certificate (clean)
Momentary failure exception (§393.9)
The required lamp was inoperative only momentarily due to vibration, temperature, or similar transient cause — explicitly exempted under §393.9.
Evidence that wins
- ✓Photograph showing the lamp operable before / after the stop
- ✓Repair invoice if a fuse or bulb was replaced
Tread measurement disputed
The tread depth measurement was taken at a worn point that is not representative, contrary to NHTSA/FMCSA measurement standards.
Evidence that wins
- ✓Independent tread gauge reading from same tire (multiple positions)
- ✓Photograph of the tire with a reference scale
Documented maintenance schedule disproves the defect
Carrier's periodic-inspection records show the cited defect could not reasonably have existed at the time of inspection.
Evidence that wins
- ✓Periodic inspection certificate (§396.17)
- ✓Maintenance work order proximate to inspection date

Common pitfalls — avoid these

⚠DataQs cannot remove a violation simply because the defect was repaired after the stop

⚡ Draft a challenge for 396.5B-HLIW →Read the DataQs guide first

More codes in Vehicle Maintenance

Same BASIC category — ranked by national citation volume

View all Vehicle Maintenance codes →

Other Wheels, Studs, Clamps, Etc. codes

Codes under the same FMCSA violation group

❓

Frequently asked questions about 396.5B-HLIW

What does violation 396.5B-HLIW mean?

396.5B-HLIW is the FMCSA roadside-inspection violation code for "Hubs - Oil and/or Grease Leaking from hub - inner wheel", part of the Wheels, Studs, Clamps, Etc. group, cited under 49 CFR §396.5B-HLIW.

What BASIC does 396.5B-HLIW affect?

396.5B-HLIW falls under the Vehicle Maintenance BASIC in the FMCSA Safety Measurement System (SMS).

What is the CSA severity weight of 396.5B-HLIW?

396.5B-HLIW carries a severity weight of 2 out of 10. Higher weights indicate violations more closely tied to crash risk, and they count more toward a carrier's Vehicle Maintenance score.

Is 396.5B-HLIW an out-of-service (OOS) violation?

No. 396.5B-HLIW is not an out-of-service violation, so on its own it does not trigger an out-of-service order at the roadside.

How many CSA points does 396.5B-HLIW add to a carrier's score?

The point contribution of 396.5B-HLIW depends on its severity weight (2/10) multiplied by a time weight of 3, 2, or 1 based on how recent the inspection is. You can calculate the exact contribution with the CSA points calculator.

Can 396.5B-HLIW be challenged through DataQs?

Yes. If you believe 396.5B-HLIW was recorded in error, you can file a Request for Data Review (RDR) through the FMCSA DataQs system with supporting evidence. A successful challenge can remove or correct the violation on your record.

Keep going

CSA points calculator How to challenge a violation Draft a DataQs letter for 396.5B-HLIW Vehicle Maintenance BASIC Carrier CSA lookup CSA glossary

396.5B-HLIW

National roadside inspection stats

Challenging 396.5B-HLIW through FMCSA DataQs

Pre-trip inspection showed compliant brakes

Momentary failure exception (§393.9)

Tread measurement disputed

Documented maintenance schedule disproves the defect