Violation code

396.5B-HLOW

Hubs - oil and/or Grease Leaking from hub - outer wheel

Vehicle Maintenance2Non-OOS· SMS Appendix A v3.20

396.5B-HLOW is a Wheels, Studs, Clamps, Etc. violation under 49 CFR §396.5B-HLOW. It falls in the Vehicle Maintenance BASIC with a severity weight of 2/10. Nationally it was cited 23,068 times in the last five years, with an OOS rate of 38.2%.

📊

National roadside inspection stats

as of 7/20/2026

Inspections

20,612

that found this code

Violations

23,068

total written

OOS rate

38.2%

8,819 OOS

Source: FMCSA roadside inspection data (last 5 years). The OOS rate is the share of these violations that led the officer to mark the driver or vehicle out of service.

Violation group: Wheels, Studs, Clamps, Etc.
Regulation §: 396.5B-HLOW
Severity weight: 2
Used in SMS: Yes
Status: Active
Updated: 7/20/2026

Last updated July 2026

⚡

Think this violation was written incorrectly?

Generate a polished DataQs challenge letter for 396.5B-HLOW in about 5 seconds. AI quotes the CFR, predicts your grant chance.

⚡ Draft a challenge →

Notes

DSMS: Y

📚

Challenging 396.5B-HLOW through FMCSA DataQs

If this violation was written incorrectly, here are the angles trucking-safety managers use to contest it. Playbook: Vehicle Maintenance (general).

Relevant 49 CFR49 CFR § 396.5

Lubrication

“Every motor carrier shall ensure that each motor vehicle subject to its control is properly lubricated and free of oil and grease leaks.”

Common ways to challenge this code

Pre-trip inspection showed compliant brakes
The driver's pre-trip DVIR documented compliant brake adjustment and operation. The cited defect arose en route or was misclassified at roadside.
Evidence that wins
- ✓Driver Vehicle Inspection Report (DVIR) from that date
- ✓Repair invoice or shop record
- ✓Post-citation re-inspection certificate (clean)
Momentary failure exception (§393.9)
The required lamp was inoperative only momentarily due to vibration, temperature, or similar transient cause — explicitly exempted under §393.9.
Evidence that wins
- ✓Photograph showing the lamp operable before / after the stop
- ✓Repair invoice if a fuse or bulb was replaced
Tread measurement disputed
The tread depth measurement was taken at a worn point that is not representative, contrary to NHTSA/FMCSA measurement standards.
Evidence that wins
- ✓Independent tread gauge reading from same tire (multiple positions)
- ✓Photograph of the tire with a reference scale
Documented maintenance schedule disproves the defect
Carrier's periodic-inspection records show the cited defect could not reasonably have existed at the time of inspection.
Evidence that wins
- ✓Periodic inspection certificate (§396.17)
- ✓Maintenance work order proximate to inspection date

Common pitfalls — avoid these

⚠DataQs cannot remove a violation simply because the defect was repaired after the stop

⚡ Draft a challenge for 396.5B-HLOW →Read the DataQs guide first

More codes in Vehicle Maintenance

Same BASIC category — ranked by national citation volume

View all Vehicle Maintenance codes →

Other Wheels, Studs, Clamps, Etc. codes

Codes under the same FMCSA violation group

❓

Frequently asked questions about 396.5B-HLOW

What does violation 396.5B-HLOW mean?

396.5B-HLOW is the FMCSA roadside-inspection violation code for "Hubs - oil and/or Grease Leaking from hub - outer wheel", part of the Wheels, Studs, Clamps, Etc. group, cited under 49 CFR §396.5B-HLOW.

What BASIC does 396.5B-HLOW affect?

396.5B-HLOW falls under the Vehicle Maintenance BASIC in the FMCSA Safety Measurement System (SMS).

What is the CSA severity weight of 396.5B-HLOW?

396.5B-HLOW carries a severity weight of 2 out of 10. Higher weights indicate violations more closely tied to crash risk, and they count more toward a carrier's Vehicle Maintenance score.

Is 396.5B-HLOW an out-of-service (OOS) violation?

No. 396.5B-HLOW is not an out-of-service violation, so on its own it does not trigger an out-of-service order at the roadside.

How many CSA points does 396.5B-HLOW add to a carrier's score?

The point contribution of 396.5B-HLOW depends on its severity weight (2/10) multiplied by a time weight of 3, 2, or 1 based on how recent the inspection is. You can calculate the exact contribution with the CSA points calculator.

Can 396.5B-HLOW be challenged through DataQs?

Yes. If you believe 396.5B-HLOW was recorded in error, you can file a Request for Data Review (RDR) through the FMCSA DataQs system with supporting evidence. A successful challenge can remove or correct the violation on your record.

Keep going

CSA points calculator How to challenge a violation Draft a DataQs letter for 396.5B-HLOW Vehicle Maintenance BASIC Carrier CSA lookup CSA glossary

Managing violations across a fleet?

Keep every violation, file, and expiration in one place

Looking up codes one at a time works for research. Running a fleet doesn’t. CY TMS — built by the same safety manager behind VioCodes — puts DQ files, CSA tracking, and compliance reminders in a single system.

$20 / truck / moLive demo · no signup

Explore CY TMS

Field notes & comments

0 comments

No comments yet — be the first.

Statistics

Most-cited violation codes

Ranked by roadside-inspection citation count across FMCSA public data.