Violation code

396.3A1BL

Brake system pressure loss

Vehicle Maintenance4Non-OOS· SMS Appendix A v3.20

396.3A1BL is a Brakes, All Others violation under 49 CFR §396.3A1BL. It falls in the Vehicle Maintenance BASIC with a severity weight of 4/10. Nationally it was cited 73,007 times in the last five years, with an OOS rate of 45.7%.

📊

National roadside inspection stats

as of 9/20/2026

Inspections

67,580

that found this code

Violations

73,007

total written

OOS rate

45.7%

33,388 OOS

Source: FMCSA roadside inspection data (last 5 years). The OOS rate is the share of these violations that led the officer to mark the driver or vehicle out of service.

Violation group: Brakes, All Others
Regulation §: 396.3A1BL
Severity weight: 4
Used in SMS: Yes
Status: Active
Updated: 9/20/2026

Last updated September 2026

⚡

Think this violation was written incorrectly?

Generate a polished DataQs challenge letter for 396.3A1BL in about 5 seconds. AI quotes the CFR, predicts your grant chance.

⚡ Draft a challenge →

Notes

DSMS: N

What 396.3A1BL means — and how to avoid it

In plain English

In plain terms, 396.3A1BL is cited for brake system pressure loss. It falls under the FMCSA rules on inspection, repair, and maintenance.

What the inspector checks

•Brake adjustment and pushrod stroke within limits
•Air loss/leaks, low-air warning, and reservoir pressure
•Cracked, worn, or contaminated linings, drums, and rotors
•Hoses/tubing chafing, kinked, or leaking

How to prevent it

✓Check brake adjustment and listen for air leaks at every pre-trip
✓Fix air leaks and warning-light faults before dispatch — don’t “drive it in”
✓Put brakes on the PM schedule and document the work

How it affects your CSA

up to 12 pts (fresh)

Severity 4/10. A fresh citation counts at the 3× time weight — up to 12 points toward the Vehicle Maintenance BASIC — then tapers to 2× after 6 months and 1× after a year, dropping off the score at 24 months.

General guidance from the violation’s FMCSA classification — not legal advice, and not a substitute for the inspector’s findings or 49 CFR.

📚

Challenging 396.3A1BL through FMCSA DataQs

If this violation was written incorrectly, here are the angles trucking-safety managers use to contest it. Playbook: Vehicle Maintenance (general).

Relevant 49 CFR49 CFR § 396.3

Inspection, repair, and maintenance

“Every motor carrier and intermodal equipment provider must systematically inspect, repair, and maintain, or cause to be systematically inspected, repaired, and maintained, all motor vehicles and intermodal equipment subject to its control.”

Common ways to challenge this code

Pre-trip inspection showed compliant brakes
The driver's pre-trip DVIR documented compliant brake adjustment and operation. The cited defect arose en route or was misclassified at roadside.
Evidence that wins
- ✓Driver Vehicle Inspection Report (DVIR) from that date
- ✓Repair invoice or shop record
- ✓Post-citation re-inspection certificate (clean)
Momentary failure exception (§393.9)
The required lamp was inoperative only momentarily due to vibration, temperature, or similar transient cause — explicitly exempted under §393.9.
Evidence that wins
- ✓Photograph showing the lamp operable before / after the stop
- ✓Repair invoice if a fuse or bulb was replaced
Tread measurement disputed
The tread depth measurement was taken at a worn point that is not representative, contrary to NHTSA/FMCSA measurement standards.
Evidence that wins
- ✓Independent tread gauge reading from same tire (multiple positions)
- ✓Photograph of the tire with a reference scale
Documented maintenance schedule disproves the defect
Carrier's periodic-inspection records show the cited defect could not reasonably have existed at the time of inspection.
Evidence that wins
- ✓Periodic inspection certificate (§396.17)
- ✓Maintenance work order proximate to inspection date

Common pitfalls — avoid these

⚠DataQs cannot remove a violation simply because the defect was repaired after the stop

⚡ Draft a challenge for 396.3A1BL →Read the DataQs guide first

More codes in Vehicle Maintenance

Same BASIC category — ranked by national citation volume

View all Vehicle Maintenance codes →

Other Brakes, All Others codes

Codes under the same FMCSA violation group

❓

Frequently asked questions about 396.3A1BL

What does violation 396.3A1BL mean?

396.3A1BL is the FMCSA roadside-inspection violation code for "Brake system pressure loss", part of the Brakes, All Others group, cited under 49 CFR §396.3A1BL.

What BASIC does 396.3A1BL affect?

396.3A1BL falls under the Vehicle Maintenance BASIC in the FMCSA Safety Measurement System (SMS).

What is the CSA severity weight of 396.3A1BL?

396.3A1BL carries a severity weight of 4 out of 10. Higher weights indicate violations more closely tied to crash risk, and they count more toward a carrier's Vehicle Maintenance score.

Is 396.3A1BL an out-of-service (OOS) violation?

No. 396.3A1BL is not an out-of-service violation, so on its own it does not trigger an out-of-service order at the roadside.

How many CSA points does 396.3A1BL add to a carrier's score?

The point contribution of 396.3A1BL depends on its severity weight (4/10) multiplied by a time weight of 3, 2, or 1 based on how recent the inspection is. You can calculate the exact contribution with the CSA points calculator.

How can a driver prevent 396.3A1BL?

Check brake adjustment and listen for air leaks at every pre-trip; Fix air leaks and warning-light faults before dispatch — don’t “drive it in”; Put brakes on the PM schedule and document the work.

Can 396.3A1BL be challenged through DataQs?

Yes. If you believe 396.3A1BL was recorded in error, you can file a Request for Data Review (RDR) through the FMCSA DataQs system with supporting evidence. A successful challenge can remove or correct the violation on your record.

Keep going

CSA points calculator How to challenge a violation Draft a DataQs letter for 396.3A1BL Vehicle Maintenance BASIC Carrier CSA lookup CSA glossary

Turn this violation into a training moment

Assign training on this exact topic — and prove it

Looking up a code is step one. FleetTrained — built by the same safety manager behind VioCodes — lets you assign a video on this topic; drivers quiz and sign in their language, and you get a DOT-ready certificate so it stops happening.