MC307 thermal device
178.342-5(a)(1) is a Package Integrity - HM violation under 49 CFR §178.342-5(a)(1). It falls in the Hazardous Materials Compliance BASIC with a severity weight of 8/10.
Last updated May 2026
Think this violation was written incorrectly?
Generate a polished DataQs challenge letter for 178.342-5(a)(1) in about 5 seconds. AI quotes the CFR, predicts your grant chance.
Notes
DSMS: NIf this violation was written incorrectly, here are the angles trucking-safety managers use to contest it. Playbook: Hazardous Materials.
Common ways to challenge this code
The materials transported did not exceed the threshold quantities requiring placards under 49 CFR Part 172 Subpart F.
Evidence that wins
This administrative code is on the inspection report but does not contribute to CSA BASIC scoring per FMCSA SMS Methodology Appendix A.
Evidence that wins
Common pitfalls — avoid these
Same BASIC category — ranked by national citation volume
HM (Packaging) - MC 330 tank must have a reflective design.
HM (Packaging) - MC 305 general requirements.
Driver - No driver shall use or permit the use of any flame-producing emergency signal for protecting any commercial motor vehicle transporting Division 1.1, Division 1.2, or Division 1.3 explosives.
HM (106A/110AW Multi-Unit Tank Car Tanks) - Improper safety relief device.
HM (Packaging) - DOT 412 general requirements.
HM (Packaging) - MC 312 improper venting requirements.
HM (Packaging) - MC 306 manhole requirements.
HM (Packaging) - MC 306/307/312 piping protection.
Codes under the same FMCSA violation group
178.342-5(a)(1) is the FMCSA roadside-inspection violation code for "MC307 thermal device", part of the Package Integrity - HM group, cited under 49 CFR §178.342-5(a)(1).
178.342-5(a)(1) falls under the Hazardous Materials Compliance BASIC in the FMCSA Safety Measurement System (SMS).
178.342-5(a)(1) carries a severity weight of 8 out of 10. Higher weights indicate violations more closely tied to crash risk, and they count more toward a carrier's Hazardous Materials Compliance score.
No. 178.342-5(a)(1) is not an out-of-service violation, so on its own it does not trigger an out-of-service order at the roadside.
The point contribution of 178.342-5(a)(1) depends on its severity weight (8/10) multiplied by a time weight of 3, 2, or 1 based on how recent the inspection is. You can calculate the exact contribution with the CSA points calculator.
Yes. If you believe 178.342-5(a)(1) was recorded in error, you can file a Request for Data Review (RDR) through the FMCSA DataQs system with supporting evidence. A successful challenge can remove or correct the violation on your record.
Keep going
Statistics
Ranked by roadside-inspection citation count across FMCSA public data.
Inoperable Required Lamp
State vehicle registration or License Plate violation
Operating a CMV without proof of a periodic inspection
Brake Out of Adjustment - Roto, Clamp (Short & Long), DD-3, or Bolt
No/discharged/unsecured fire extinguisher
Inoperative turn signal
Operating a CMV without documentation of a periodic inspection.
Tire-flat and/or audible air leak
Wipers - Inoperative / missing / damaged wipers.
Violation of Local Laws - Explain:
State/Local Laws - State registration/tag violation.
Emergency Equipment - Stopped vehicle warning devices missing or impr…
State/Local Laws - Speeding 6-10 miles per hour over the speed limit.
Brake - Defective brake(s) are equal to or greater than 20% of the se…
No or defective lighting devices or reflective material as required
Inspection, repair and maintenance of parts and accessories
CMV manufactured after 10/19/94 has an automatic airbrake adjustment …
Tire-other tread depth less than 2/32 of inch measured in a major tre…
Tires - All others, leaking or inflation less than 50% of the maximum…
Carrier name and/or USDOT Number not displayed as required