ORION CARTAGE INC
Risk factors
Low riskVioCodes scoreA weighted read of the public FMCSA signals below — authority, insurance, out-of-service, crashes, roadside OOS rates, and carrier connections. A starting point for vetting, not a guarantee.
Roadside inspection performance
Out-of-service rate vs national average. Lower is better.
CSA performance breakdown
FMCSA · August 28, 20268 inspections · 35 violations (6 OOS) · 50% of inspections had an OOS finding.
Violations by BASIC
click to filter codes
Top cited codes
score = count × severity weight
- 1393.9TSVehicle Maint.
Inoperative turn signal
12
2× · sev 6
- 2393.45B2UVVehicle Maint.
Brake Hose or Tubing Chafing and/or Kinking Under Vehicle
8
2× · sev 4
- 3393.75(a)(1)Vehicle Maint.
Tire-ply or belt material exposed
8
1× · sev 8
- 4396.3(a)(1)Vehicle Maint.1 OOS
Tire in contact with another part of the vehicle
8
1× · sev 8
- 5393.11TLVehicle Maint.
Truck-Tractor lower rear mud flaps retroreflective sheeting / reflex reflective material requirements for vehicles manufactured after July 1997
6
2× · sev 3
- 6393.11TUVehicle Maint.
Truck-Tractor upper body corner requirements for retroreflective sheeting or reflex reflective material for vehicles manufactured after July 1997
6
2× · sev 3
- 7393.9Vehicle Maint.
Inoperable Required Lamp
6
3× · sev 2
- 8393.45B2PCVehicle Maint.1 OOS
Brake Hose or Tubing Chafing and/or Kinking - Connection to Power Unit
4
1× · sev 4
- 9393.47(b)Vehicle Maint.1 OOS
Mis-matched brake chambers on same axle
4
1× · sev 4
- 10393.47(e)Vehicle Maint.
Brake Out of Adjustment - Roto, Clamp (Short & Long), DD-3, or Bolt
4
1× · sev 4
Most inspected in · top 1 states
- TX8
Latest FMCSA SMS snapshot. Codes link to the lookup — severity weighting, contest angles, and the DataQs Drafter for each. Click a BASIC to filter the codes.
Safety trends & next-run projection
Where each BASIC sits today, how it ranks against peers, and where it’s heading at the next monthly SMS run.
FMCSA keeps the Crash Indicator percentile private, and its measure needs a power-unit history public data doesn’t expose — so it can’t be estimated yet. VioCodes now records power units monthly, so a calibrated Crash estimate should light up over time. These are the public crash facts (all state-reportable crashes count, regardless of fault).
“Projected” estimates the next monthly SMS run from inspections on record now. FMCSA marks the BASIC percentile itself “Not Public,” so the percentile shown is a VioCodes estimate of how the carrier ranks against its peers, presented as a likely range (shaded on the gauge) and calibrated against real carriers. Crash Indicator has no public estimate — FMCSA keeps its measures fully private. Estimates, not official FMCSA figures. Not affiliated with FMCSA.
Recommendations
What’s driving each score, what to do about it, and where it could go.
Vehicle out-of-service rate exceeds the national average
High impactVehicle OOS rate is 62.5% vs the 22% national average. Carriers above the national OOS average draw more enforcement attention (audits, roadside stops) and can see higher insurance premiums.
- Review recent inspections with out-of-service violations and fix the root causes with equipment and drivers
- Run a preventative-maintenance program; periodically inspect tires, brakes and lights
- Reinforce thorough pre-trip and post-trip inspections; retrain where needed
Recommendations are generated from the carrier’s public FMCSA roadside-inspection record. Percentiles and projections are VioCodes estimates, not official FMCSA figures. Informational, not legal advice.
90-day safety improvement plan
What this carrier has struggled with most in the last 90 days — where to focus now.
- 393.11A1-CSLRR×2Conspicuity Systems - Truck tractor, lower rear retro reflective sheeting missing on vehicle manufactured on or after July 1, 1997
- 393.207A-SUBLSuspension - U-bolt, u-bolt bottom plate, or other axle clamp bolt loose/cracked/broken/missing. · OOS
- 393.9A-LBLLighting - Backup lamp inoperative
- Walk the lights every pre-trip and carry spare bulbs/fuses
- Clean lenses and check the trailer plug for corrosion
- 390.21TB2-DOTOperate a CMV without USDOT number displayed. Must be preceded by the letters USDOT
- 393.47EBrake Out of Adjustment - Roto, Clamp (Short & Long), DD-3, or Bolt
- 396.3A1-BOSBrake - Defective brake(s) are equal to or greater than 20% of the service brakes on the vehicle/combination · OOS
- Review these violations with drivers and add the fix to your pre-trip and PM routine
Based on roadside inspections in the last 90 days, ranked by what recurs most. Informational, not legal advice.
Inspection & crash map
live · FMCSA MCMISEvery inspection and crash on record — hover a point for the summary, click for full detail (codes, severity, CSA points).
CSA points = violation severity weight × FMCSA time weight (3× in the last 6 months, 2× at 6–12, 1× at 12–24). Points are spread within each state — FMCSA records the inspection state, not an exact location. Source: FMCSA MCMIS.
Equipment
VINs via NHTSA5 distinct vehicles seen in this carrier’s roadside inspections.
Equipment is inferred from VINs recorded on roadside inspections (FMCSA MCMIS), decoded via the NHTSA vPIC API — it reflects vehicles inspected, not a current fleet roster.
Company profile
FMCSA censusAUTHORIZED FOR HIRE
- Intrastate · <100 mi3 drivers
- Company officer
- GUSTAVO HERNANDEZ
- Operation
- Intrastate (Non-Hazmat)
- Registered since
- 2017-06-01
- Last MCS-150 update
- 2026-02-03
- Census status
- Active
Fleet: 3 trucks · 3 owned tractors · 3 owned trailers.
Source: FMCSA Company Census File (data.transportation.gov). Fleet and driver counts are self-reported on the carrier’s most recent MCS-150 filing.
Connections
carrier graphThis carrier shares VINs, phone numbers or officers with 31 other carriers — review the connections below as part of your vetting.
Shared VINs come from FMCSA roadside-inspection records — a vehicle inspected under more than one carrier, often a fleet transfer or trailer interchange. Other links come from the FMCSA census. Shared identifiers are common and often legitimate — treat these as leads to investigate, not proof of wrongdoing.
Activity history
2 events- 02/03/2026MCS-150 update filed
0.1M mi reported (2025)
- 06/01/2017Registered with FMCSA
AUTHORIZED FOR HIRE
Merged from FMCSA authority, insurance, out-of-service, and census records.
Operations
Classification
- AUTHORIZED FOR HIRE
Area served
- Intrastate (Non-Hazmat)
FMCSA safety rating
- Rating
- Not rated
- Type
- —
- Rated
- —
- Last review
- —
MCS-150 registration
- Form date
- 2026-02-03
- Reported mileage
- 120,000 mi (2025)
Got a violation you want to contest?
Use the free AI-powered DataQs Drafter to generate a polished challenge letter — quotes the relevant 49 CFR, predicts your grant chance.