CARSUSTAR INDUSTRIAL
Legal: CARAUSTAR INDUSTRIAL AND CONSUMER PRODUCTS GROUP INC
Risk factors
Low riskVioCodes scoreA weighted read of the public FMCSA signals below — authority, insurance, out-of-service, crashes, roadside OOS rates, and carrier connections. A starting point for vetting, not a guarantee.
Roadside inspection performance
Out-of-service rate vs national average. Lower is better.
CSA performance breakdown
FMCSA · Sep 2026106 inspections · 9 violations (2 OOS) · 7% of inspections had an OOS finding.
Violations by BASIC
click to filter codes
Top cited codes
score = count × severity weight
- 1392.2-SLLSWZUnsafe Driving
State/Local Laws - Speeding work/construction zone
10
1× · sev 10
- 2392.2-SLLMLUnsafe Driving
State/Local Laws - Failure to maintain lane
5
1× · sev 5
- 3392.2-SLLTCDUnsafe Driving
State/Local Laws - Failed to obey a traffic control device - Permanent or Temporary - e.g., safety official, signal, sign, light, lane marking, other
5
1× · sev 5
- 4393.9Vehicle Maintenance1 OOS
Inoperable Required Lamp
4
2× · sev 2
- 5392.2-SLLS2Unsafe Driving
State/Local Laws - Speeding 6-10 miles per hour over the speed limit
4
1× · sev 4
- 6393.11B-CSURRVehicle Maintenance
Conspicuity Systems - Trailers, upper rear retro reflective sheeting inadequate on vehicle manufactured on or after December 1, 1993
3
1× · sev 3
- 7392.2-SLLTL
State/Local Laws - Misc. traffic law violation
1
1×
- 8393.75A31 OOS
Tire-flat and/or audible air leak
1
1×
Most inspected in · top 8 states
- TX11
- NC7
- OH3
- GA3
- OK3
- SC1
- FL1
- UT1
Latest FMCSA SMS snapshot. Codes link to the lookup — severity weighting, contest angles, and the DataQs Drafter for each. Click a BASIC to filter the codes.
Safety trends & next-run projection
Where each BASIC sits today, how it ranks against peers, and where it’s heading at the next monthly SMS run.
FMCSA keeps the Crash Indicator percentile private, and its measure needs a power-unit history public data doesn’t expose — so it can’t be estimated yet. VioCodes now records power units monthly, so a calibrated Crash estimate should light up over time. These are the public crash facts (all state-reportable crashes count, regardless of fault).
“Projected” estimates the next monthly SMS run from inspections on record now. FMCSA marks the BASIC percentile itself “Not Public,” so the percentile shown is a VioCodes estimate of how the carrier ranks against its peers, presented as a likely range (shaded on the gauge) and calibrated against real carriers. Crash Indicator has no public estimate — FMCSA keeps its measures fully private. Estimates, not official FMCSA figures. Not affiliated with FMCSA.
Recommendations
What’s driving each score, what to do about it, and where it could go.
Phone / texting violations are the leading contributor to Unsafe Driving
Low impactEstimated Unsafe Driving percentile of 23% is under the 65% line. In decent shape, but here's what's driving it.
- 392.82DUMTDriver - Using a hand-held mobile telephone3× · 28%
- 392.2-SLLCPState/Local Laws - Operate a CMV while using a cellular phone1× · 9%
- 392.2-SLLSWZState/Local Laws - Speeding work/construction zone1× · 18%
- 392.2-SLLS2State/Local Laws - Speeding 6-10 miles per hour over the speed limit1× · 11%
- 392.2-SLLTCDState/Local Laws - Failed to obey a traffic control device - Permanent or Temporary - e.g., safety official, signal, sign, light, lane marking, other1× · 14%
- 392.2-SLLMLState/Local Laws - Failure to maintain lane1× · 14%
- Hands-off-the-phone policy with real consequences; provide a mount and a do-not-disturb setup
Controlled Substances/Alcohol needs attention
Low impactEstimated Controlled Substances/Alcohol percentile of 0% is under the 80% line. In decent shape, but here's what's driving it.
- Review recent inspections with violations in this BASIC and take remedial action with drivers/equipment
Lighting / lamps violations are the leading contributor to Vehicle Maintenance
Low impactEstimated Vehicle Maintenance percentile of 26% is under the 80% line. In decent shape, but here's what's driving it.
- 393.9Inoperable Required Lamp3× · 13%
- 393.9A-LFTSILighting - Front - Turn signal - inoperative2× · 8%
- 393.9A-LSLIWRLighting - Stop lamps - Both inoperative when required to be on1× · 5%
- 393.75A3-TAOLTires - All others, leaking or inflation less than 50% of the maximum inflation pressure on tire not equipped with ATIS4× · 25%
- 393.75C-TAOTD-LT2/32Tires - Less than 2/32 inch tread depth1× · 5%
- 393.45B2-B-AIRAir Brake - Hose/tubing damaged or not secured3× · 8%
- 393.45Brake tubing and hose adequacy1× · 4%
- 393.48A-BIBDDrum Brake - Inoperative other than a steering axle1× · 3%
- 393.134B-CRHLCRoll-on/Roll-off/Hook Lift Containers - Improper securement of a roll-on/roll-off and hook lift container1× · 6%
- 392.9A-DFSLDriver - Failing to properly secure load1× · 1%
- Walk the lights every pre-trip and carry spare bulbs/fuses; clean lenses and check the trailer plug
- Prioritize the out-of-service items — they carry the heaviest weight
Recommendations are generated from the carrier’s public FMCSA roadside-inspection record. Percentiles and projections are VioCodes estimates, not official FMCSA figures. Informational, not legal advice.
90-day safety improvement plan
What this carrier has struggled with most in the last 90 days — where to focus now.
- 392.2-SLLTCDState/Local Laws - Failed to obey a traffic control device - Permanent or Temporary - e.g., safety official, signal, sign, light, lane marking, other
- 392.2-SLLS2State/Local Laws - Speeding 6-10 miles per hour over the speed limit
- Walk the lights every pre-trip and carry spare bulbs/fuses
- Clean lenses and check the trailer plug for corrosion
- 393.9×2Inoperable Required Lamp · OOS
- Walk the lights every pre-trip and carry spare bulbs/fuses
- Clean lenses and check the trailer plug for corrosion
- 393.75A3Tire-flat and/or audible air leak · OOS
- Gauge/thump every tire on the walk-around, including inner duals
- Replace before tread hits the limit and correct low pressure immediately
Based on roadside inspections in the last 90 days, ranked by what recurs most. Informational, not legal advice.
Inspection & crash map
live · FMCSA MCMISEvery inspection and crash on record — hover a point for the summary, click for full detail (codes, severity, CSA points).
CSA points = violation severity weight × FMCSA time weight (3× in the last 6 months, 2× at 6–12, 1× at 12–24). Points are spread within each state — FMCSA records the inspection state, not an exact location. Source: FMCSA MCMIS.
Equipment
VINs via NHTSA89 distinct vehicles seen in this carrier’s roadside inspections.
+ 59 more.
Equipment is inferred from VINs recorded on roadside inspections (FMCSA MCMIS), decoded via the NHTSA vPIC API — it reflects vehicles inspected, not a current fleet roster.
Crash record (US, last 24 months)
Total
3
Tow-away
2
Injury
1
Fatal
0
Company profile
FMCSA censusPRIVATE PROPERTY
- Interstate · 100+ mi79 drivers
- Interstate · <100 mi19 drivers
- Company officer
- TERRY ATKINS
- Operation
- Interstate
- D-U-N-S
- 106356280
- Registered since
- 1974-06-01
- Last MCS-150 update
- 2026-05-07
- Census status
- Active
Fleet: 69 trucks · 686 owned trailers · 62 leased/term tractors.
Source: FMCSA Company Census File (data.transportation.gov). Fleet and driver counts are self-reported on the carrier’s most recent MCS-150 filing.
Connections
carrier graphThis carrier shares VINs, addresses, phone numbers, officers or emails with 20 other carriers — review the connections below as part of your vetting.
Shared VINs come from FMCSA roadside-inspection records — a vehicle inspected under more than one carrier, often a fleet transfer or trailer interchange. Other links come from the FMCSA census. Shared identifiers are common and often legitimate — treat these as leads to investigate, not proof of wrongdoing.
Activity history
2 events- 05/07/2026MCS-150 update filed
3.2M mi reported (2024)
- 06/01/1974Registered with FMCSA
PRIVATE PROPERTY
Merged from FMCSA authority, insurance, out-of-service, and census records.
Operations
Classification
- PRIVATE PROPERTY
Area served
- Interstate
FMCSA safety rating
- Rating
- Satisfactory
- Type
- Safety audit
- Rated
- 1988-06-06
- Last review
- 1988-05-02
MCS-150 registration
- Form date
- 2026-05-07
- Reported mileage
- 3,235,000 mi (2024)
Changes on file
FMCSA census historyNovember, 2022
- Moved to SMYRNA, GA
May, 2021
- Name changed to "CARAUSTAR INDUSTRIAL AND CONSUMER PRODUCTS GROUP INC"
- DBA changed to "CARSUSTAR INDUSTRIAL"
January, 2021
First on-record entry — CARAUSTAR INDUSTRIAL INC, ,
Got a violation you want to contest?
Use the free AI-powered DataQs Drafter to generate a polished challenge letter — quotes the relevant 49 CFR, predicts your grant chance.